Lably
Skip to content

Aircraft diesel engine

Aircraft engine operating on the Diesel principle

  • 16 min read
  • 4 chapters

Related on Lably

Through World War II, Soviet Union and Helicopter

Lab · Class 8–10India's Freedom StruggleLab · Class 8National MovementLab · Class 8–12Helicopter & VTOL Physics

Using diesel engines in aircraft is additionally advantageous from the standpoint of environmental protection as well as the protection of human health, since the tetraethyllead antiknock ingredient of avgas has long been known to be highly toxic as well as polluting.

Development

Early diesel aircraft

A number of manufacturers built diesel aero engines in the 1920s and 1930s; the best known were the Packard air-cooled radial, and the Junkers Jumo 205, which was moderately successful, but proved unsuitable for combat use in World War II. The Blohm & Voss BV 138 trimotor maritime patrol flying boat, however, was powered with the more developed Junkers Jumo 207 powerplant, and was more successful with its trio of diesel Jumo 207s conferring upwards of a maximum 2,100 km (1,300 mile) combat radius upon the nearly 300 examples of the BV 138 built during World War II.

The first successful diesel engine developed specifically for aircraft was the Packard DR-980 radial diesel of 1928–1929, which was laid out in the familiar air-cooled radial format similar to Wright and Pratt & Whitney designs, and was contemporary with the Beardmore Tornado used in the R101 airship. The use of a diesel had been specified for its low fire risk fuel. The first successful flight of a diesel powered aircraft was made on September 18, 1928, in a Stinson model SM-1DX Detroiter registration number X7654. Around 1936 the heavier but less thirsty diesel engines were preferred over gasoline engines when flight time was over only 6–7 hours.

Entering service in the early 1930s, the two-stroke Junkers Jumo 205 opposed-piston engine was much more widely used than previous aero diesels. It was moderately successful in its use in the Blohm & Voss Ha 139 and even more so in airship use. In Britain Napier & Son license-built the larger Junkers Jumo 204 as the Napier Culverin, but it did not see production use in this form. A Daimler-Benz diesel engine was also used in Zeppelins, including the ill-fated LZ 129 Hindenburg. This engine proved unsuitable in military applications and subsequent German aircraft engine development concentrated on gasoline and jet engines.

The Soviet World War II-era four-engine strategic bomber Petlyakov Pe-8 was built with Charomskiy ACh-30 diesel engines; but just after the war's end, both its diesels, and gasoline-fueled Mikulin inline V12 engines for surviving Pe-8 airframes were replaced with Shvetsov-designed radial gasoline engines because of efficiency concerns. The Yermolaev Yer-2 long-range medium bomber was also built with Charomskiy diesel engines.

Other manufacturers also experimented with diesel engines in this period, such as the French Bloch (later Dassault Aviation), whose MB203 bomber prototype used Clerget diesels of radial design. The Royal Aircraft Establishment developed an experimental compression ignition (diesel) version of the Rolls-Royce Condor in 1932, flying it in a Hawker Horsley for test purposes.

Postwar development

Interest in diesel engines in the postwar period was sporadic. The lower power-to-weight ratio of diesels, particularly compared to turboprop engines, weighed against the diesel engine. With fuel available cheaply and most research interest in turboprops and jets for high-speed airliners, diesel-powered aircraft virtually disappeared. The stagnation of the general aviation market in the 1990s saw a massive decline in the development of any new aircraft engine types.

Napier & Son in Britain had developed the Napier Culverin, a derivative of the Junkers Jumo 205, before World War II, and took up aero diesel engines again in the 1950s. The British Air Ministry supported the development of the 2,200 kW (3,000 hp) Napier Nomad, a combination of piston and turboprop engines, which was exceptionally efficient in terms of brake specific fuel consumption, but judged too bulky and complex and canceled in 1955.

Modern developments

Several factors have emerged to change this equation. First, a number of new manufacturers of general aviation aircraft developing new designs have emerged. Second, in Europe in particular, avgas has become very expensive. Third, in several (particularly remote) locations, avgas is harder to obtain than diesel fuel. Finally, automotive diesel technologies have improved greatly in recent years, offering higher power-to-weight ratios more suitable for aircraft application.

Certified diesel-powered light planes are currently available, and a number of companies are developing new engine and aircraft designs for the purpose. Many of these run on readily available jet fuel (kerosene), or on conventional automotive diesel.

Simulations indicate lower maximum payload due to the heavier engine, but also longer range at medium payload.

Sign in to keep reading

3 more chapters are free with a Lably account.

More in Transportation

Rail transportMode of transportCarMotorised passenger road vehiclePublic transportShared transportation service for use by the general publicTransportMovement of goods or people between locationsRapid transitHigh-capacity public transportCanalArtificial channel for water